|
|
论文:2020,Vol:38,Issue(4):855-861 |
|
|
引用本文： |
|
|
陈吉明, 吴盛豪, 陈振华, 吕金磊, 裴海涛. 连续式跨声速风洞回路吸声降噪技术试验研究[J]. 西北工业大学学报 |
|
|
CHEN Jiming, WU Shenghao, CHEN Zhenhua, LYU Jinlei, PEI Haitao. Experimental Research on Noise Reduction for Continuous Transonic Wind Tunnel Loop[J]. Northwestern polytechnical university |
|
|
|
|
|
|
|
| 连续式跨声速风洞回路吸声降噪技术试验研究 |
|
| 陈吉明1,2, 吴盛豪1, 陈振华1, 吕金磊1,2, 裴海涛1 |
|
1. 中国空气动力研究与发展中心 空气动力学国家重点实验室, 四川 绵阳 621000;
2. 中国空气动力研究与发展中心 设备设计及测试技术研究所, 四川 绵阳 621000 |
| 摘要: |
| 风洞试验段噪声（气流压力脉动）是评价风洞流场的重要指标之一，对高品质流场要求的大型风洞设计提出了严峻挑战。通过中国空气动力研究与发展中心（CARDC）0.6 m连续式跨声速风洞沿程回路噪声测试，分析得到风洞主要噪声源为：风洞压缩机、高速扩散段（含二喉道段）、试验段本身（含模型支架段）。其中，来自试验段上游的压缩机噪声必须通过沿程回路吸声降噪措施进行隔离。提出了压缩机尾罩段洞壁和整流罩尾椎采用微穿孔板，风洞第四拐角段导流片填充复合吸声材料2种降噪方案，均取得了良好的降噪效果。最终通过试验段自身通气壁壁板参数优化等主动降噪方案，并采用风洞二喉道节流状态抑制试验段下游噪声前传的措施，实现风洞试验段压力脉动系数ΔCp≤0.8%的噪声设计指标要求。 |
| 关键词:
连续式风洞
跨声速风洞
洞体回路
被动降噪
试验研究
|
|
| Experimental Research on Noise Reduction for Continuous Transonic Wind Tunnel Loop |
|
| CHEN Jiming1,2, WU Shenghao1, CHEN Zhenhua1, LYU Jinlei1,2, PEI Haitao1 |
|
1. State Key Laboratory of Aerodynamics, China Aerodynamics Research and Development Center, Mianyang 621000, China;
2. Facility Design and Instrument Institute, China Aerodynamics Research and Development Center, Mianyang 621000, China |
| Abstract: |
| The noise level of wind tunnel test section is respected as one of the most important performance specifications to represent the flow field quality, especially for large scale wind tunnel. According to the acoustic experimental research conducted in the 0.6 m continuous transonic wind tunnel of CARDC, main noise sources in the tunnel loop included the compressor, the high-speed diffuser and the test section. To reduce the noise in the test section, it is necessary to prevent the test section from the compressor noise propagated both forward and backward. In 0.6 m wind tunnel loop, acoustic treatments were installed on both the compressor rear cone and the fourth corner to prevent the noise emitted from the compressor from propagating forward. The vanes in the forth corner were filled with glass fibers and covered with perforated panels. And the compressor rear cone was covered with three layers of micro-perforated panels. With acoustic treatment in the tunnel loop and the second throat throttling,the fluctuation pressure coefficient (ΔCp) is lower than 0.8%, which is close to the international advanced level. |
| Key words:
continuous wind tunnel
transonic wind tunnel
noise reduction
experiment
acoustic treatment
|
|
| 收稿日期: 2019-09-19
修回日期:
|
| DOI: 10.1051/jnwpu/20203840855 |
| 基金项目: 国家自然科学基金（51936010）资助 |
| 通讯作者:
Email： |
| 作者简介: 陈吉明(1975-),中国空气动力研究与发展中心副研究员,主要从事气动力设备设计及试验研究。
|
|
|
|
|
|
|
|
参考文献: |
|
|
[1] 廖达雄,陈吉明,彭强,等. 连续式跨声速风洞设计关键技术. 实验流体力学, 2011,25(4):74-78 LIAO Daxiong, CHEN Jiming, PENG Qiang, et al. Key Design Techniques of the Low Noise Continuous Transonic Wind Tunnel[J]. Journal of Experiments in Fluid Mechanics, 2011, 25(4):74-78(in Chinese)
[2] MABEY D G. Flow Unsteadiness and Model Vibration in Wind Tunnels at Subsonic and Transonic Speeds[R]. C.P.No.1155, 1970
[3] LOWSON M V. Prediction of Boundary Layer Pressure Fluctuations[R]. AFFDL-TR-67-167, 1967
[4] DENNIS G M. Some Remarks on the Design of Transonic Tunnels with Low Levels of Flow Unsteadiness[R]. NASA CR-2722, 1976
[5] 陈玉清,谷嘉锦. 跨音速风洞低噪声控制阀的试验研究[J]. 噪声与振动控制, 1986(5):44-48 CHEN Yuqing, GU Jiajin. Experimental Study on Low Noise Control Valve of the Transonic Wind Tunnel[J]. Noise and Vibration Control, 1986(5):44-48(in Chinese)
[6] 龚卫斌. 降低跨、超声速风洞噪声的方法[J]. 气动实验与测量控制, 1993(4):28-33 GONG Weibin. The Methods for Eliminating the Noise from the Transonic-Supersonic Wind Tunnel[J]. Aerodynamics Experiment and Measurement & Control, 1993(4):28-33(in Chinese)
[7] 恽起麟. 降低0.6 m×0.6 m跨声速风洞气流噪声的研究[J]. 空气动力学学报,1985(2):51-60 YUN Qilin. The Research for Reducing 0.6 m×0.6 m Transonic Wind Tunnel Aeroacoustics[J]. Acta Aerodynamica Sinica, 1985(2):51-60(in Chinese)
[8] 胡成行. 国内跨超音速风洞噪声特性综述[J]. 气动实验与测量控制, 1987(2):1-6 HU Chenghang. A Review of Transonic-Supersonic Wind Tunnel Noise Characteristics in China[J]. Aerodynamics Experiment and Measurement & Control, 1987(2):1-6(in Chinese)
[9] 谷嘉锦. 跨声速风洞试验段低噪声壁板模型的声学试验[J]. 空气动力学学报,2001,19(1):62-65 GU Jiajian. Transonic Wind Tunnel Acoustical Experiment of Low Noise Wall Models for Test Section[J]. Acta Aerodynamica Sinica, 2001,19(1):62-65(in Chinese)
[10] 陈玉清,谷嘉锦. 跨音速风洞的噪声机理[J]. 南京航空航天大学学报, 1982(2):85-94 CHEN Yuqing, GU Jiajin. The Noise Mechanism of Transonic Wind Tunnel[J]. Journal of Nanjing University of Aeronautics & Astronautics, 1982(2):85-94(in Chinese)
[11] 吕金磊,盛美萍,廖达雄, 等. 基于实验的跨声速风洞试验段噪声机理研究[J]. 空气动力学学报, 2014, 32(4):488-492 LYU Jinlei, SHENG Meiping, LIAO Daxiong, et al. Investigation About Transonic Wind Tunnel Test Section Noise Mechanism Based on Experimental[J]. Acta Aerodynamica Sinica, 2014, 32(4):488-492(in Chinese)
[12] 廖达雄,陈吉明,郑娟,等. 0.6 m连续式跨声速风洞总体性能[J]. 实验流体力学, 2018,32(6):74-78 LIAO Daxiong, CHEN Jiming, ZHENG Juan, et al. General Performance of 0.6 m Continuous Transonic Wind Tunnel[J]. Journal of Experiments in Fluid Mechanics, 2018, 32(6):74-78(in Chinese)
[13] DAVIS M W. Optimum Transonic Wind Tunnel[C]//AIAA 14th Aerodynamic Testing Conference, 1986
[14] 伍荣林,王振羽. 风洞设计原理[M]. 北京:北京航空学院出版社,1985 WU Ronglin, WANG Zhenyu. Wind Tunnel Design Principle[M]. Beijing:Beijing Aeronautical Institute Press, 1985(in Chinese) |
|
|
|
|
|
|
|
