论文:2018,Vol:36,Issue(6):1129-1138
引用本文:
雷涛, 蔺子存, 张晓斌, 李龙春. 热平衡移相控制策略在双有源桥DC-DC变换器的应用研究[J]. 西北工业大学学报
Lei Tao, Lin Zicun, Zhang Xiaobin, Li Longchun. Application of Thermal Balance Phase-Shift Control Strategy to Dual-Active-Bridge DC-DC Converter[J]. Northwestern polytechnical university

热平衡移相控制策略在双有源桥DC-DC变换器的应用研究
雷涛, 蔺子存, 张晓斌, 李龙春
西北工业大学 自动化学院, 陕西 西安 710072
摘要:
随着飞机电气系统向多电化和全电化发展,机载储能装置的使用对双有源桥(dual-active-bridge,DAB) DC-DC变换器性能要求不断提高。DAB变换器中功率开关器件的热损耗影响着器件的使用寿命,因此也影响了变换器可靠性,所以对功率开关器件进行热平衡控制是一项很重要的指标。先通过对扩展移相控制策略下的航空DAB DC-DC变换器的工作模态和开关热不平衡现象进行分析和实验验证,找到轻载条件下难以实现软开关的原因,以及一次侧超前桥臂与滞后桥臂软开关条件的差异,从而提出一种在原有控制基础上的新型热平衡移相控制策略。通过时基交替控制模式和温度反馈控制模式2种方式进行控制效果实验,最终通过观测变换器热成像温度分布图、整机效率计算以及开关波形分析,验证了提出的算法实现功率器件热平衡控制方法的有效性,该方法可以提高变换器效率,减小器件应力,从而提高了DAB变换器的可靠性,提升器件寿命。
关键词:    双有源桥    谐振电容    软开关    热平衡移相控制   
Application of Thermal Balance Phase-Shift Control Strategy to Dual-Active-Bridge DC-DC Converter
Lei Tao, Lin Zicun, Zhang Xiaobin, Li Longchun
School of Automation, Northwestern Polytechnical University, Xi'an 710072, China
Abstract:
With the development of the more/All electrical aircraft technology, the dual active bridge converter has been applied to the energy storage device to realize the bidirectional power flow in aircraft electrical system. The power loss of power device in DAB converter affects the operational life of the device and the reliability of the converter. So it is an important performance index to keep the temperature balance for power device in DAB converter. In this paper, the operational mode of dual active bridge bidirectional DC-DC converter in extended-phase-shift (EPS) control is analyzed and verified by experiment, find the reasons for difficult to achieve soft-switching under light load conditions, then proposes a novel thermal balance phase-shift control strategy on the basis of EPS. Experimental methods in this paper are alternation control mode and temperature feedback control mode. The thermal image and temperature was analyzed. The efficiency curve was plotted. The switching waveform was observed. the thermal balance was achieved to verify the effectiveness. and finally achieves the goal for improving the converter efficiency, reduces the devices heat stress, improves the reliability of the DAB converters and increases device lifetime.
Key words:    dual-active-bridge    resonant capacitor    soft-switching    thermal balance phase-shift   
收稿日期: 2017-12-20     修回日期:
DOI:
基金项目: 中央高校基本科研业务费自主前瞻布局类(3102015BJ(Ⅱ)ZS027)资助
通讯作者:     Email:
作者简介: 雷涛(1974-),西北工业大学副教授、硕士生导师,主要从事电力电子先进控制技术研究。
相关功能
PDF(3296KB) Free
打印本文
把本文推荐给朋友
作者相关文章
雷涛  在本刊中的所有文章
蔺子存  在本刊中的所有文章
张晓斌  在本刊中的所有文章
李龙春  在本刊中的所有文章

参考文献:
[1] 雷志方,汪飞,高艳霞,等. 面向直流微网的双向DC-DC变换器研究现状和应用分析[J]. 电工技术学报,2016,31(22):138-147 Lei Zhifang, Wang Fei, Gao Yanxia, et al. Research Status and Application Analysis of Bidirectional DC-DC Conversters in DC Micro-Grids[J]. Transactions of China Electro-Technical Society, 2016, 31(22):138-147(in Chinese)
[2] 李立,刘刚. 多电池组储能系统双向DC-DC变换器的研制[J]. 电力系统保护与控制,2011,39(3):91-94 Li Li, Liu Gang. Development of Bi-Directional DC-DC Converter in Multiple Battery Energy Storage System[J]. Power System Protection and Control, 2011, 39(3):91-94(in Chinese)
[3] 许正平,李俊. 双向全桥DC-DC变换器高效能控制研究与实现[J]. 电力系统保护与控制,2016,44(2):141-146 Xu Zhengping, Li Jun. Research and Implementation of Bidirectional Full Bridge DC-DC Converter with High-Efficiency Control[J]. Power System Protection and Control, 2016, 44(2):141-146(in Chinese)
[4] Rodriguez A, Vazquez A, Lamar D G, et al. Different Purpose Design Strategies and Techniques to Improve the Performance of a Dual Active Bridge With Phase-Shift Control[J]. IEEE Trans on Power Electron, 2015, 30(2):790-804
[5] A Garcia-Bediaga, Rujas A, Mir L, et al. Multiobjective Optimization of Medium-Frequency Transformers for Isolated Soft-Switching Converters Using a Genetic Algorithm[J]. IEEE Trans on Power Electron, 2017, 32(4):2995-3006
[6] Riedel J, Holmes D G, McGrath B P, et al. ZVS Soft Switching Boundaries for Dual Active Bridge DC-DC Converters Using Frequency Domain Analysis[J]. IEEE Trans on Power Electron, 2017, 32(4):3166-3179
[7] 高明远. 双向DC-DC变换器基于切换系统的建模与储能控制[J]. 电力系统保护与控制, 2012, 40(3):130-134 Gao Mingyuan. Modeling and Energy Storage Control for Bi-Directional DC-DC Converter Based on Switching System[J]. Power System Protection and Control, 2012, 40(3):130-134(in Chinese)
[8] Zhao B, Song Q, Liu W, et al. Overview of Dual-Active-Bridge Isolated Bidirectional DC-DC Converter for High-Frequency-Link Power-Conversion System[J]. IEEE Trans on Power Electron, 2014, 29(8):4091-4106
[9] Zhao B, Song Q, Liu W, et al. Transient DC Bias and Current Impact Effects of High-Frequency-Isolated Bidirectional DC-DC Converter in Practice[J]. IEEE Trans Power Electron, 2014, 29(8):4091-4106
[10] Yuri Panov, Milan M Jovanovic, Brian T Irving. Novel Transformer-Flux-Balancing Control of Dual-Active-Bridge Bidirectional Converters[C]//IEEE Applied Power Electronics Conference and Exposition, 2015:42-49
[11] German G Oggier, Martin Ordonez. High-Efficiency DAB Converter Using Switching Sequences and Burst Mode[J]. IEEE Trans on Power Electronics, 2016, 31(3):2069-2082
[12] Wooin Choi, Kyung-Min Rho, Bo-Hyung Cho. Fundamental Duty Modulation of Dual-Active-Bridge Converter for Wide-Range Operation[J]. IEEE Trans on Power Electronics, 2016, 31(6):4048-4064
[13] Tong A, Hang L, li G, et al. Modeling and Analysis of Dual-Active-Bridge Isolated Bidirectional DC/DC Converter to Minimize RMS Current With Whole Operating Range[J]. IEEE Trans on Power Electronics, 2018, 33(6):5302-5316
[14] Taylor Allan, Liu Guangliang, Bai Hua, et al. Mutiple-Phase-Shift Control for a Dual Active Bridge to Secure Zero-Voltage-Switching and Enhanced Light-Load Performance[J]. IEEE Trans on Power Electronics, 2018, 33(6):4584-4588
[15] 赵彪,于庆广,孙伟欣. 双重移相控制的双向全桥DC-DC变换器及其功率回流特性分析[J]. 中国电机工程学报, 2012, 32(12):43-50 Zhao Biao, Yu Qingguang, Sun Weixin. Bi-Directional Full-Bridge DC-DC Converters with Dual-Phase-Shifting Control and Its Backflow Power Characteristic Analysis[J]. Proceedings of the China. Society for Electrical Engineering, 2012, 32(12):43-50(in Chinese)
[16] 程红, 高巧梅, 朱锦标, 等. 基于双重移相控制的双向全桥DC-DC变换器动态建模与最小回流功率控制[J]. 电工技术学报, 2014, 29(3):245-253 Cheng Hong, Gao Qiaomei, Zhu Jinbiao, et al. Dynamic Modeling and Minimum Backflow Power Controlling of the Bi-Directional Full-Bridge DC-DC Converters Based on Dual-Phase-Shifting Control[J]. Transactions of China Electro-Technical Society, 2014, 29(3):245-253(in Chinese)
[17] 王聪,沙广林,王俊,等. 基于双重移相控制的双有源桥DC-DC变换器的软开关[J]. 电工技术学报, 2015, 30(12):106-113 Wang Cong, Sha Guanglin, Wang Jun, et al. The Analysis of Zero Voltage Switching Dual Active Bridge DC-DC Converters Based on Dual-Phase-Shifting Control[J]. Transactions of China Electro-Technical Society, 2015, 30(12):106-113(in Chinese)
[18] Lai Y S, Su Z J, Chang Y T. Novel Phase-Shift Control Technique for Full-Bridge Converter to Reduce Thermal Imbalance under Light-Load Condition[J]. IEEE Trans Ind Appl, 2015, 51(2):1651-1659
[19] Chen B Y, Lai Y S. Switching Control Technique of Phase-Shift Controlled Full-Bridge Converter to Improve Efficiency under Light-Load and Standby Conditions Without Additional Auxiliary Components[J]. IEEE Trans on Power Electron, 2010, 25(4):1001-1012
[20] Pahlevani M, Pan S, Jain P. A Hybrid Phase-Shift Modulation Technique for DC/DC Converters with a Wide Range of Operating Conditions[J]. IEEE Trans on Industrial Electronics, 2016, 63(12):7498-7510
[21] Burkart R M, Kolar J W. Comparative η-ρ-σ Pareto Optimization of Si and SiC Multilevel Dual-Active-Bridge Topologies with Wide Input Voltage Range[J]. IEEE Trans on Power Electron, 2017, 32(7):5258-5270
[22] Chakraborty S, Chattopadhyay S. Minimum-RMS-Current Operation of Asymmetric Dual Active Half-Bridge Converters with and without ZVS[J]. IEEE Trans on Power Electron, 2017, 32(7):5132-5145