论文:2018,Vol:36,Issue(4):728-734
引用本文:
夏冶宝, 任兴民, 杨永锋. 航空发动机动力涡轮转子悬臂分支结构建模与结构参数影响分析[J]. 西北工业大学学报
Xia Yebao, Ren Xingmin, Yang Yongfeng. Modeling Cantilever Branch Structure of Aero-Engine Power Turbine and Analyzing Its Influence[J]. Northwestern polytechnical university

航空发动机动力涡轮转子悬臂分支结构建模与结构参数影响分析
夏冶宝, 任兴民, 杨永锋
西北工业大学 振动工程研究所, 陕西 西安 710072
摘要:
针对某型动力涡轮转子特殊的悬臂分支结构,建立了带分支转盘系统的转子动力学模型,该模型包含了分支系统主要的结构设计参数,推导了其运动微分方程,通过数值方法求解了转子系统的振型、临界转速和不平衡响应,对比了有无考虑分支结构时的计算结果,重点研究了调节分支结构参数,如分支轴长度、法兰盘偏置量、分支安装方位等对系统动力特性的影响。研究表明:分支结构对转子系统的振型、临界转速等存在重要影响,计算时不应简化忽略;调节分支结构参数不会改变转子系统的振型属性,其对临界转速的调节效果与相应振型密切相关;增大分支轴长度、减小法兰盘偏置量以及反向安装分支,会减小转子系统的抗弯刚度,降低临界转速,同时带来涡轮盘处不平衡响应急剧增大的问题。因此,针对分支结构参数进行合理设计,可以对转子系统的动力学特性进行优化和调整。
关键词:    动力涡轮转子    悬臂分支    建模    结构参数    动力学特性   
Modeling Cantilever Branch Structure of Aero-Engine Power Turbine and Analyzing Its Influence
Xia Yebao, Ren Xingmin, Yang Yongfeng
Institute of Vibration Engineering, Northwestern Polytechnical University, Xi'an 710072, China
Abstract:
In the power turbine component of an aero-engine, there exists a unique cantilever branch structure, on which turbine disks are mounted. Due to the cantilever's characteristics, this structure exhibits a vibration of large amplitude;thus its characteristics need to be studied in detail.In this paper,the motion equations combining the structure and the shaft were deduced; then its vibration mode was given, and the criticl speed was computed; finally the unbalance response of an integrated rotor system was simulated.The calculation results are compared with the simulation results without considering the branch structure.Some key parameters' influences are studied thoroughly, e.g., the branch shaft's length, the flange's offset and the installation orientation. As the results show, the branch structure has a large influence on the vibration mode and critical speed of the rotor system, thus it should not be simplified and ignored in modelling; After adjusting the branch structure's parameters, the characteristics of a vibration mode do not change, and the effects of branch structural parameters on critical speed are closely related to the corresponding vibration mode; the bending stiffness and the critical speed of the rotor system both decreased with increasing branch shaft's length; if reducing the flange's offset and fabricating the branch structure reversely, a sharp increase in the unbalance response of the turbine disc will occur. In conclusion, the dynamical characteristics of the integrated rotor system can be optimized through reasonably designing the branch structure.
Key words:    turbine rotor    cantilever branch    modeling    structural parameter    dynamic characteristics   
收稿日期: 2017-08-10     修回日期:
DOI:
基金项目: 国家自然科学基金(11272257)资助
通讯作者:     Email:
作者简介: 夏冶宝(1989-),西北工业大学博士研究生,主要从事转子瞬态动平衡研究。
相关功能
PDF(2129KB) Free
打印本文
把本文推荐给朋友
作者相关文章
夏冶宝  在本刊中的所有文章
任兴民  在本刊中的所有文章
杨永锋  在本刊中的所有文章

参考文献:
[1] 陈予恕, 张华彪. 航空发动机整机动力学研究进展与展望[J]. 航空学报, 2011, 32(8):1371-1391 Chen Yushu, Zhang Huabiao. Review and Prospect on the Research of Dynamics of Complete Aero-Engine Systems[J]. Acta Aeronautica et Astronautica Sinica, 2011, 32(8):1371-1391(in Chinese)
[2] Chiang H W D, Hsu C N, Tu S H. Rotor-Bearing Analysis for Turbomachinery Singleand Dual-Rotor Systems[J]. Journal of Propulsion & Power, 2004, 20(6):1096-1104
[3] 陈果. 双转子航空发动机整机振动建模与分析[J]. 振动工程学报,2011,24(6):619-632 Chen Guo. Vibration Modeling and Analysis for Dual-Rotor Aero-Engine[J]. Journal of Vibration Engineering, 2011, 24(6):619-632(in Chinese)
[4] 陈果. 航空发动机整机振动耦合动力学模型及其验证[J]. 航空动力学报, 2012, 27(2):241-254 Chen Guo. A Coupling Dynamic Model for Whole Aero-Engine Vibration and Its Verification[J]. Journal of Aerospace Power, 2012, 27(2):241-254(in Chinese)
[5] 路振勇, 陈予恕, 李洪亮,等. 航空发动机转子系统动力学模型的可逆化简化方法[J]. 航空动力学报, 2016, 31(1):57-64 Lu Zhenyong, Chen Yushu, Li Hongliang, et al. Reversible Model-Simplifying Method for Aero-Engine Rotor Systems[J]. Journal of Aerospace Power, 2016, 31(1):57-64(in Chinese)
[6] 黄晶晶, 郑龙席, 王治武,等. 双盘转子系统动力特性分析及优化设计[J]. 推进技术, 2014, 35(11):1530-1536 Huang Jingjing, Zheng Longxi, Wang Zhiwu, et al. Dynamical Characteristics Analysis and Optimization of a Two-Disk Rotor System[J]. Journal of Propulsion Technology, 2014, 35(11):1530-1536(in Chinese)
[7] 黄晶晶, 郑龙席, 刘钢旗,等. 双盘转子系统优化算法与试验[J]. 航空动力学报, 2016, 31(1):65-71 Huang Jingjing,Zheng Longxi,Liu Gangqi, et al. Optimization Algorithm and Experiment of a Two-Disk Rotor System[J]. Journal of Aerospace Power, 2016, 31(1):65-71(in Chinese)
[8] 廖明夫, 谭大力, 耿建明,等. 航空发动机高压转子的结构动力学设计方法[J]. 航空动力学报, 2014, 29(7):1505-1519 Liao Mingfu, Tan Dali, Geng Jianming, et al. Structure Dynamics Design Method of Aero-Engine High Pressure Rotor[J]. Journal of Aerospace Power, 2014, 29(7):1505-1519(in Chinese)
相关文献:
1.柳子栋, 詹浩, 邓阳平.复杂环境下运输类飞机拦阻着舰建模与动力学特性分析[J]. 西北工业大学学报, 2013,31(5): 816-823