|
|
论文:2017,Vol:35,Issue(6):935-940 |
|
|
引用本文： |
|
|
刘光辉, 周军, 马学龙. 基于COTS器件的纳级卫星反作用飞轮的设计[J]. 西北工业大学学报 |
|
|
Liu Guanghui, Zhou Jun, Ma Xuelong. Design of Reaction Wheels Based on COTS Device for Nano-Satellite[J]. Northwestern polytechnical university |
|
|
|
|
|
|
|
| 基于COTS器件的纳级卫星反作用飞轮的设计 |
|
| 刘光辉, 周军, 马学龙 |
|
| 西北工业大学 航天学院, 陕西 西安 710072 |
| 摘要: |
| 针对纳级卫星的任务需求，设计了一种基于商用货架器件（commercial off the shelf components、COTS）、模块化的低成本反作用飞轮方案。采用非密闭式结构，无刷电机驱动轮缘式轮盘，两者之间振动模态分析结果表明不存在共振问题；控制器采用积分分离控制算法，基于超低功耗处理器捕获霍尔信号测速，驱动MOSFET桥换相。所研制飞轮成功通过了地面性能与环境试验测试，实测结果：重量63 g，尺寸/mm为36×36×28，最大转速9 000 r/min，最大角动量≥ 5.5 mNms，输出力矩为≥ 0.2 mNm，功耗≤ 500 mW。2016年6月25日，该飞轮随世界首颗12U立方星"翱翔之星"即西北工业大学首颗卫星，搭载"长征7号"发射入轨，在轨服役99天直到卫星坠入大气层，工作状态良好。地面测试与飞行验证结果均表明：基于COTS的飞轮设计方案有效可行，满足卫星任务需求。 |
| 关键词:
微型飞轮
反作用飞轮
COTS
纳级卫星
立方星
角速度
角动量
无刷电机
控制器
实验测试
振动分析
|
|
| Design of Reaction Wheels Based on COTS Device for Nano-Satellite |
|
| Liu Guanghui, Zhou Jun, Ma Xuelong |
|
| School of Astronautics, Northwestern Polytechnical University, Xi'an 710072, China |
| Abstract: |
| In this paper, a modular micro-reaction wheel based on Commercial off the Shelf Components (COTS) is designed to meet the mission requirements of nano-satellites. The system is guided by open box-shaped structure and the flywheel is drived by brushless DC motor(BLDCM), which can avoid the resonance problem according to vibration mode analysis. The controller uses the integral separation control algorithm and based on Ultra-low-power processor to capture the Hall Signal speed and drive the MOSFET bridge to change phase. The proposed flywheel has successfully passed the ground test and environmental test, the measured flywheel parameters are as follows:mass 63 g, size 36 mm×36 mm×28 mm, maximum speed 9 000 r/min, maximum angular momentum ≥ 5.5 mNms, torque ≥ 0.2 mNm, power consumption ≤ 500 mW. On June 25, 2016, the flywheel as part of the world's first 12U CubeSat "Star of AoXiang", which is the first satellite of Northwestern Polytechnic University, launched into the orbit along with "CZ-7" and served as the actuator for 99 days with excellent working conditions, until it fell into the atmosphere. Both the ground test experiment and the flight verification results show that the proposed COTS flywheel can meet the mission requirements for nano-satellite and CubeSat. |
| Key words:
micro-flywheel
reaction wheels
COTS
nano-satellite
CubeSat
angular velocity
angular momentum
BLDCM
controllers
experiment test
vibration analysis
|
|
| 收稿日期: 2017-02-12
修回日期:
|
| DOI: |
| 基金项目: 国家自然科学基金（61231016）资助 |
| 通讯作者:
Email： |
| 作者简介: 刘光辉(1983-),西北工业大学助理研究员、博士,主要从事星载/弹载电气系统、执行机构研究。
|
|
| 相关功能 |
|
|
|
|
| 作者相关文章 |
|
| 刘光辉 在本刊中的所有文章 |
| 周军 在本刊中的所有文章 |
| 马学龙 在本刊中的所有文章 |
|
|
|
|
|
|
|
|
参考文献: |
|
|
[1] Sinclair D, Cordell C, Zee R E. Enabling Reaction Wheel Tecnology for High Performance Nanosatellite Attitude Control[J]. Journal of the Chemical Society Transactions, 2007, 52(15):1326-1331
[2] Jayaram S. Design and Analysis of Nano Momentum Wheel for Picosatellite Attitude Control System[J]. Aircraft Engineering and Aerospace Technology, 2009, 81(5):424-431
[3] 王辉. 小卫星用姿态控制飞轮系统关键技术研究[D]. 长春:中国科学院长春光学精密机械与物理究所, 2015 Wang Hui. Research on Key Technology of Attitude Control Flywheel System for Small Satellites Application[D]. Changchun:Changchun Institute of Optics, Fine Mechanics and Physics Chinese Academy of Sciences, 2015(in Chinese)
[4] 姜宁翔, 许辰, 孙丹, 等. 微型反作用飞轮技术[J]. 上海控制, 2013, 30(4):90-95 Jiang Ningxiang, Xu Chen, Sun Dan, et al. Miniaturization Reaction Flywheel Technology[J]. Aerospace Shanghai, 2013, 30(4):90-95(in Chinese)
[5] Bouwmeester J, Reijneveld J, Hoevenaars T, et al. Design and Verification of A Very Compact and Versatile Attitude Determination and Control System for the Delfi-n3Xt Nanosatellite[C]//Proceedings of the 4S(Small Satellites Systems and Services) Symposium. Slovenia:CNES/ESA, 2014:1-15
[6] H Kayal, F Baumann, K Briess, et al. Verification of Miniaturized Reaction Wheels for Pico and Nano Satellites[C]//6th ESA Round Table on Micro & Nano Technologies for Space Applications, Switzerland, 2008:1-14
[7] Bozovic G, Scaglione O, Koechli C, et al. SwissCube:Development of An Ultra-light and Efficient Inertia Wheel for the Attitude Control and Stabilization of CubeSat Class Satellites[C]//59th International Astronautical Congress 2008 Scotland, 4175-4182
[8] Oland E, Schlanbusch R. Reaction Wheel Design for CubeSats[C]//International Conference on Recent Advances in Space Technologies, 2009:778-783
[9] Hoevenaars T, Engeleny S, Bouwmeester J. Model-Based Discrete PID Controller for CubeSat Reaction Wheels Using COTS Bushless DC Motors[C]//Proceedings of the 1st IAA Conference on Dynamics and Control of Space Systems. Portugal, 2012, 145:379-394 |
|
|
|
相关文献: |
|
|
1．黄伟, 徐建城, 吴佳斌, 吴华兴.导弹协同编队H∞制导律设计[J]. 西北工业大学学报, 2017,35(5): 767-773 |
|
|
2．陈熠, 刘冲冲, 牟让科.舰载机舰面操纵转弯特性动力学建模与分析[J]. 西北工业大学学报, 2017,35(6): 1089-1095 |
|
|
3．黄伟, 徐建城, 李俊兵, 吴华兴.基于BiSAR制导的战斗机最优引导律及导弹最优制导律设计[J]. 西北工业大学学报, 2016,34(3): 367-373 |
|
|
4．杨立本, 章卫国, 黄得刚, 车军.欠驱动四旋翼飞行器反演模糊自适应控制[J]. 西北工业大学学报, 2015,33(3): 495-499 |
|
|
|
|
|
|
