|
|
论文:2015,Vol:33,Issue(6):1020-1026 |
|
|
引用本文： |
|
|
吕云嵩, 王育荣, 邹政耀. 变惯量飞轮-液压变压器-马达辅助液压激振[J]. 西北工业大学学报 |
|
|
Lü Yunsong, Wang Yurong, Zou Zhengyao. Hydro-Vibration Assisted by Flywheel-Hydraulic transformer-Motor[J]. Northwestern polytechnical university |
|
|
|
|
|
|
|
| 变惯量飞轮-液压变压器-马达辅助液压激振 |
|
| 吕云嵩, 王育荣, 邹政耀 |
|
| 南京工程学院 机械工程学院, 江苏 南京 211167 |
| 摘要: |
| 针对阀控液压激振低能效的缺陷,提出一种新的激振方法。以作动缸、液压变压器和液压马达组成闭式回路,作动缸活塞杆连接振体,液压马达传动轴连接变量飞轮。振体振动时带动作动缸输出交变压力油,经变压器变压,驱动液压马达和飞轮摆动。飞轮摆动时其转动惯量能够跟踪振体运动节奏变化,在飞轮和振体之间引发动量循环,强化振动。动量循环没有节流损失,故而节能。液压变压器变压比调节范围大,弥补了大排量液压马达高频特性不良的缺陷,能有效扩展振动特性调节范围。构建了系统数学模型,对激振系统动力学性能进行了理论分析和Matlab仿真,表明变量飞轮的激振效果可通过变压系数和飞轮惯量调节系数调节,在适当条件下激振效果明显。 |
| 关键词:
变量飞轮
液压变压器
液压激振
节能
|
|
| Hydro-Vibration Assisted by Flywheel-Hydraulic transformer-Motor |
|
| Lü Yunsong, Wang Yurong, Zou Zhengyao |
|
| School of Mechanical Engineering, Nanjing Institute of Technology, Nanjing 211167, China |
| Abstract: |
| In view of the low energy efficiency of the hydro-vibration controlled by valve, a new method of vibration is put forward. An actuator and a hydro-motor constitute a closed circuit via a hydro-transformer. A vibrator is connected to the actuator, and the hydro-motor is connected to a variable inertia flywheel. When the vibrator vibrates, the actuator will be driven to pump alternating pressure oil, the motor with the flywheel is then driven to swing via the hydro-transformer. The rotating inertia of the flywheel can be changed according to the motion phase of the vibrator, momentum cycles will thus arise between the flywheel and the vibrator and theirs vibration is intensified. There is no throttling loss in this way unlike the vibration controlled by valve, it is energy saving. Having large adjusting range in transformer ratio the transformer could compensate the insufficient performance of the motor of large displacement at high frequency, and the adjusting range of vibration frequency could be extended. Theoretical analysis and Matlab simulation shows that the vibration could be adjusted by the transformer ratio and the rate of momentum change of the flywheel, and the vibration can be intensified obviously under proper conditions. |
| Key words:
actuators
computer
simulation
differential equations
transformer
energy conservation
energy efficiency
engine cylinder
engine piston
flywheels
Laplace transforms
Matlab
momentum
motor
natural frequency
sensor
springs
valves
vibrator variable inertia flywheel hydro-transformer hydro-vibration energy conservation
|
|
| 收稿日期: 2015-04-28
修回日期:
|
| DOI: |
| 基金项目: 江苏省自然科学基金(BK2012866)与江苏高校科研成果产业化推进项目(JHB2011-26)资助 |
| 通讯作者:
Email： |
| 作者简介: 吕云嵩(1957—),南京工程学院教授,主要从事液压控制与液压节能技术研究。
|
|
|
|
|
|
|
|
参考文献: |
|
|
[1] 陈章位,于慧君. 振动控制技术现状与发展[J]. 振动与冲击,2009, 28(3): 73-77 Chen Zhangwei, Yu Huijun. Existing State and Development of Vibration Control Technology[J]. Journal of Vibration and Shock,2009,28(3):73-77 (in Chinese)
[2] 邢彤,左强,杨永帅,等. 液压激振技术的研究进展[J]. 中国机械工程,2012,23(3):362-36 Xing Tong, Zuo Qiang, Yang Yongshuai, et al. Progresses of Research on Hydraulic Vibration Technology[J]. China Mechanical Engineering, 2012, 23(3):362-367 (in Chinese)
[3] 陆春月,寇子明,吴娟,等. 以管路为振动输出源的液压激振系统研究[J]. 液压与气动,2013(2):32-34 Lu Chunyue, Kou Ziming, Wu Juan, et al. Research on the Hydraulic Vibration System with the Vibration Output Source of Pipe[J]. Chinese Hydraulics & Pneumatics,2013(2):32-34 (in Chinese)
[4] 栾强利,陈章位,贺惠农,等. 三级阀控液压振动台控制策略研究[J]. 振动与冲击,2014(24):138-143 Luan Qiangli, Chen Zhangwei, He Huinong,et al. Control Strategy for a Hydraulic Shaker Controlled with a 3-Stage Electro-Hydraulic Servo Valve[J]. Journal of Vibration and Shock, 2014(24):138-143 (in Chinese)
[5] 关广丰,王海涛,熊伟,等. 六自由度液压振动台运动学分析及控制策略[J]. 振动、测试与诊断,2011,31(1):89-93 Guan Guangfeng, Wang Haitao, Xiong Wei, et al. Kinematic Analysis and Control Strategy of 6-DOF Hydraulic Vibration Table[J]. Journal of Vibration Measurement& Diagnosis,2011, 31(1):89-93 (in Chinese)
[6] 邱法维,沙锋强,王刚,等. 地震模拟振动台控制技术及软件研究[J]. 液压与气动,2011(6):98-101 Qiu Fawei, Sha Fengqiang, Wang Gang, et al. Shaking Table Control Technology and Software Research[J]. Chinese Hydraulics & Pneumatics,2011,(6):98-101 (in Chinese)
[7] Yang Zhidong, Huang Qitao, Han Junwei, et al. Adaptive Inverse Contol of Random Vibration Based on the Filtered X LMS Algorithm[J]. Eanhquake Engineering & Engineering Vibration, 2010,9(1):141-146
[8] Tagawa Y, Kajiwara K. Controller Development for the E-Defense Shaking Table[J]. Proceedings of the Institution of Mechanical Engineers, PartⅠ:Journal of Systems and Control Engineering, 2007,221(2):171-181
[9] 阮健,李胜,裴翔,等. 2D阀控电液激振器[J]. 机械工程学报, 2009,45(11):125-132 Ruan Jian, Li Sheng, Pei Xiang, et al. Electrohvdraulic Vibration Exciter Controlled by 2D Valve[J]. Journal of Mechanical Engineering, 2009, 45(11): 125-132 (in Chinese)
[10] 徐兵,马吉恩,杨华勇. 液压变压器瞬时流量特性分析[J]. 机械工程学报,2007, 43(11):44-49 Xu Bing, Ma Jien, Yang Huayong, et al. Analysis of Instantaneous Flow Rate Character of Hydraulic Transformer[J]. Journal of Mechanical Engineering,2007,43(11): 44-49 (in Chinese)
[11] 张树忠,邓斌,柯坚. 基于液压变压器的挖掘机动臂势能再生系统[J]. 中国机械工程,2010, 21(10):1161-1166 Zhang Shuzhong, Deng Bin, Ke Jian, et al. Research on Energy Regeneration System of Hydraulic Excavator's Boom Based on Hydraulic Transformer[J]. China Mechanical Engineering, 2010, 21(10):1161-1166 (in Chinese)
[12] 吕云嵩. 转盘式变量飞轮[P]. CN201110449564, 2012-11-28 Lü Yunsong. Rotating Disk Variable Inertia Wheel[P]. CN201110449564, 2012-11-28 (in Chinese)
[13] 吕云嵩. 基于变量飞轮的节能型液压振动系统及其工作方式[P]. CN201110449545.7, 2012-11-28 Lü Yunsong. Energy Conservation Hydro-Vibration System and Operating Principles Based on Variable Inertia Wheel[P]. CN201110449545, 2012-11-28 |
|
|
|
|
|
|
|
