|
|
Articles:2023,Vol:28,Issue(1):1-11 |
|
|
Citation: |
|
|
WANG Liang. Fault Analysis and Structure Optimization of Traveling Transmission System of Shuttle Car[J]. International Journal of Plant Engineering and Management, 2023, 28(1): 1-11 |
|
|
|
|
|
|
|
| Fault Analysis and Structure Optimization of Traveling Transmission System of Shuttle Car |
|
| WANG Liang |
|
| China Coal Science and Industry Group, Chinese Institute of Coal Science, Beijing 100013, China |
| Abstract: |
| This paper firstly introduces the common faults of traveling transmission system of shuttle car. Secondly, by analyzing the characteristics of shuttle car structure, the layout of traveling transmission system and the common faults on shuttle car, this paper concludes that "internal holding torque" is the main cause of faults. Finally, this paper proposes a corresponding optimization design scheme to reduce the impact of "internal torque", and calculates the relevant results through the finite element simulation analysis method. Through these analyses and calculations, it is shown that the method can effectively reduce the probability of failure of traveling transmission system of shuttle car. |
| Key words:
shuttle car
traveling transmission system
fault analysis
structure optimization
|
|
| Received: 2022-09-16
Revised:
|
| DOI: 10.13434/j.cnki.1007-4546.2023.0101 |
| Funds: This paper was supported by the Key Project of China Coal Technology and Engineering Group, under Grant (No. 2020-2-TD-ZD003). |
| Corresponding author:
Email： |
| Author description:
|
|
|
|
|
|
|
|
References: |
|
|
[1] DENG X P. Analysis and treatment of the traveling electrical fault of joy 10SC32-48B shuttle car[J]. Shaanxi Coal, 2020,39(S2):84-87+70(in Chinese)
[2] XIE W C. Research on inter wheel differential control strategy of in wheel drive electric vehicle[D]. Anhui University of engineering, 2015(in Chinese)
[3] YU Y C. Research on vehicle driving anti-skid performance and control strategy[D]. Zhejiang University of technology, 2016(in Chinese)
[4] YAO B W. Research on dynamic response of transmission shaft system under impact load[D]. Xi'an University of Electronic Science and technology, 2021(in Chinese)
[5] LIN M Y, ZHANG F S. Vehicle chassis structure and design[M]. Beijing:Metallurgical Industry Press, 2007(in Chinese)
[6] LI H. Research on structure and properties of high strength spring steel[D]. Northeast University, 2019(in Chinese) |
|
|
|
|
|
|
|
