|
|
论文:2022,Vol:40,Issue(1):182-188 |
|
|
引用本文： |
|
|
邓景辉. 组合式液弹隔振器传递特性分析及试验研究[J]. 西北工业大学学报 |
|
|
Deng Jinghui. Theoretical modeling and experimental study of fluid-elastic isolator[J]. Northwestern polytechnical university |
|
|
|
|
|
|
|
| 组合式液弹隔振器传递特性分析及试验研究 |
|
| 邓景辉 |
|
| 中国直升机设计研究所, 江西 景德镇 333001 |
| 摘要: |
| 液弹隔振器作用在直升机主传递通道上，能大幅降低旋翼传递到机身的振动载荷，是一种直接有效的隔振方式，在国外已被广泛研究并实现工程应用。根据动力反共振原理建立了组合式液弹隔振器模型，并基于广义Lagrange方程推导了其动力学方程。研究了液弹隔振器传递特性随参数的变化规律，并据此针对某民用直升机振动特性完成液弹隔振器主要参数设计。制作隔振器原理样件并开展组合式液弹隔振器传递特性试验，采用扫频方式考察液弹隔振器在不同激励频率及激振位移幅值下的位移传递率。结果表明，理论分析与试验结果具有较好的一致性，在3种激振幅值下，所设计的隔振器在反共振点仅有30%的位移传递率，表明组合式液弹隔振器具有较好隔振效率。理论分析显示液弹隔振器隔振效果受到多种设计参数的综合影响，针对特定隔振频率，需统筹完成隔振器参数设计。 |
| 关键词:
液弹隔振器
动力反共振
参数影响分析
位移传递率
隔振试验
|
|
| Theoretical modeling and experimental study of fluid-elastic isolator |
|
| Deng Jinghui |
|
| China Helicopter Research and Development Institute, Jingdezhen 333001, China |
| Abstract: |
| The fluid-elastic vibration isolator, mounted on the final reduction channel of a helicopter, could reduce the vibration acting on the airframe effectively. It is an efficient approach to vibration load isolation, therefore has been studied and employed vastly abroad. A fluid-elastic vibration isolator is designed based on the theory of dynamic anti-vibration isolation. The equation of motion is derived by applying the Lagrange principle. Parametric study is carried out to investigate the dynamic performance with varying parameters. Then the main design parameters are determined on the basis of the vibration characteristics of a civil helicopter. Experiments are conducted on the fluid-elastic vibration isolator; the performances are evaluated for different excitation displacements employing the frequency-sweeping technique. Theoretical analysis indicates that the performance of an isolator is the overall effect of various parameters, therefore all the factors should be considered for a specific isolation frequency. Experimental results reveal that the fluid-elastic vibration isolator demonstrates only a 30% of displacement transfer rate. The theoretical analysis is in good agreement with the experimental finding. Experiments with different excitation displacements show that the displacement transfer rate increases slightly with the increase of the displacement. |
| Key words:
fluid elastic vibration isolator
dynamic anti-resonance
parametric influence analysis
displacement transfer rate
vibration isolation experiment
|
|
| 收稿日期: 2021-05-10
修回日期:
|
| DOI: 10.1051/jnwpu/20224010182 |
| 基金项目: 航空科学基金（2016ZA02005）资助 |
| 通讯作者:
Email： |
| 作者简介: 邓景辉(1965—),中国直升机设计研究所总设计师,主要从事直升机旋翼研究。e-mail:807432293@qq.com
|
|
|
|
|
|
|
|
参考文献: |
|
|
[1] 张晓谷. 直升机动力学设计[M]. 北京:航空工业出版社,1995 ZHANG Xiaogu. The design of helicopter dynamics[M]. Beijing:Aviation Industry Press,1995(in Chinese)
[2] 张呈林, 张晓谷, 郭士龙, 等. 直升机部件设计[M]. 南京:南京航空航天大学出版社, 2008 ZHANG Chenglin, HANG Xiaogu, GUO Shilong, et al. The design of helicopter components[M]. Nanjing:Nanjing University of Aeronautics and Astronautics Press, 2008(in Chinese)
[3] HALWES D R. Live-liquid inertia vibration eliminator[C]//American Helicopter Society 36th Annual Forum,Washington, 1980
[4] LI Weihua, ZHANG Xianzhou, DU Haiping. Development and simulation evaluation of a magnetorheological elastomer isolator for seat vibration control[J]. Journal of Intelligent Material Systems and Structures, 2012, 23(9):1041-1048
[5] YANG Jian, DU Haiping, LI Weihua, et al. Experimental study and modeling of a novel magnetorheological elastomer isolator[J]. Smart Material and Structures, 2013, 22:117001
[6] TAMER Aykut, VINCENZO Muscarello, PIERANGELO Masarati, et al. Evaluation of vibration reduction devices for helicopter ride quality improvement[J]. Aerospace Science and Technology, 2019, 95:105456
[7] 邓旭东. 直升机高性能主减隔振系统分析与仿真研究[D]. 南京:南京航空航天大学, 2010 DENG Xudong. Research on simulation for the advanced helicopter gearbox isolation system[D]. Nanjing:Nanjing University of Aeronautics and Astronautics, 2010(in Chinese)
[8] KYLE R. Vibration analysis and testing of bell 429 helicopter[C]//American Helicopter Society 66th Annual Forum, Phoenix Arizona, 2010
[9] RODRIGUES Jonathan, CRANGA Paul, CHESNE Simon, et al. Hybrid active suspension system of a helicopter main gearbox[J]. Journal of Vibration and Control, 2016, 24(5):956-974
[10] MCGURIE Dennis P. High stiffness ("Rigid") helicopter pylon vibration isolation systems[C]//American Helicopter Society 59th Annual Forum, Phoenix, Arizona, 2003
[11] HAN Dong, RAHN Christopher D, SMITH Edward C. Higher harmonic pitch link loads reduction using fluidlatic isolators[J]. Journal of Aerospace Engineering, 2014, 228(3):455-469
[12] SUN S S, YANG J, LI W H, et al, Development of an isolator working with magnetorheological elastomers and fluids[J]. Mechanical Systems and Signal Processing, 2017, 83:371-384
[13] LENG Dingxin, SUN Songlei, XU Kai, et al. A physical model of magnetorheological elastomer isolator and its dynamic analysis[J]. Journal of Intelligent Material Systems and Structures, 2020, 31(9):1141-1156
[14] 龚亮. 液弹隔振器设计分析与试验研究[D]. 南京:南京航空航天大学,2010 GONG Liang. Design and testing of the fluid elastomer isolator[D]. Nanjing:Nanjing University of Aeronautics and Astronautics, 2010(in Chinese)
[15] 冯志壮, 钱峰, 程起有, 等. 新型液弹隔振器设计与仿真[J]. 航空学报, 2017, 38(增刊1):721530 FENG Zhizhuang, QIAN Feng, CHENG Qiyou, et al. Design and simulation for new fluid elastomer vibration isolator[J]. Acta Aeronautica et Astronautica Sinica, 2017, 38(suppl 1):721530(in Chinese)
[16] CHENG Qiyou, DENG Jinghui, QIAN Feng, et al. Dynamic performance analysis and design for a fluidlastic isolator[C]//International Conference on Robotics, Control and Automation, Guangzhou, China, 2019:26-28
[17] CHENG Qiyou, DENG Jinghui, FENG Zhizhuang, et al. Analysis of material parameter effects on fluidlastic isolators perfor-mance[C]//International Conference on New Material and Chemical Industry, 2018
[18] 钱峰, 程起有, 代志雄. 液弹隔振器设计与试验分析[J]. 装备环境工程, 2020(9):52-57 QIAN Feng, CHENG Qiyou, DAI Zhixiong. Design and test analysis of fluidlastic isolator[J]. Equipment Environmental Engineering, 2020(9):52-57(in Chinese)
[19] DENG Jinghui, Cheng Qiyou. Sensitivity analysis of design parameters on fuidlasic isolators pemormce[C]//International Workshop on Materials, Chemistry and Engineering, 2018
[20] DENG Jinghui, Cheng Qiyou. Analysis of design parameters effects on vibration characteristics of fluidlastic isolators[C]//International Conference on Mechanics and Mechatronics Research, 2017 |
|
|
|
|
|
|
|
