论文:2021,Vol:39,Issue(3):549-557
引用本文:
陈鹏翔, 贺尔铭, 姚瀚宇, 黄峻峰, 舒俊成. 大型回转网状天线风阻计算及其对动平衡影响研究[J]. 西北工业大学学报
CHEN Pengxiang, HE Erming, YAO Hanyu, HUANG Junfeng, SHU Juncheng. Wind resistance calculation of large rotary mesh antenna and its influence on dynamic balance precision[J]. Northwestern polytechnical university

大型回转网状天线风阻计算及其对动平衡影响研究
陈鹏翔, 贺尔铭, 姚瀚宇, 黄峻峰, 舒俊成
西北工业大学 航空学院, 陕西 西安 710072
摘要:
在地面动平衡配平试验中,由于大型回转网状天线主反射器受风阻的影响,卫星天线难以得到正确配平结果。为了解决这一问题,对大型回转网状天线在低压环境与地面标准大气压环境中风阻影响下的动平衡问题进行了研究。以理论分析及圆柱绕流二维试验数据为基础,提出了基于CFD三维流场分析的大型回转网状天线风阻计算方法,将回转状态下网状天线主反射器的分布风阻等效为作用点位于各象限的主矢、主矩,进而通过动力学等效法转化为配平面上的偏心质量,为估算风阻对大型网状天线动平衡精度的影响从而补偿风阻效应提供了一条可行的创新途径。结合某型星载网状天线地面动平衡需求,建立了网状天线的整体有限元模型,进行了地面动平衡配平试验仿真,分析了风阻对天线地面动平衡配平结果的影响,为补偿风阻影响、保证天线在轨配平精度提供了重要数据。
关键词:    大型网状天线    动平衡试验    风阻等效    圆柱绕流   
Wind resistance calculation of large rotary mesh antenna and its influence on dynamic balance precision
CHEN Pengxiang, HE Erming, YAO Hanyu, HUANG Junfeng, SHU Juncheng
School of Aeronautics, Northwestern Polytechnical University, Xi'an 710072, China
Abstract:
Due to the wind resistance which acts on the main reflector of large rotary mesh antenna, the correct balancing result of satellite antenna is difficult to be gotten in the ground dynamic balancing test. In order to solve this problem, the dynamic balance method of large rotary mesh antenna which is under the influence of wind resistance in both low pressure environment and standard atmospheric pressure environment on the ground is studied. Based on the theoretical analysis and the experimental data of two-dimensional flow around circular cylinder, a new method of the large rotary mesh antenna wind resistance calculation is proposed, according to the CFD analysis of the three dimensional flow field. Through the dynamic equivalent method, the distributed wind resistance acted on the main reflector of the mesh antenna in the rotating state is equivalent to the principal vector and principal moment of the action point in each quadrant, and then transformed into the eccentric mass on the distribution plane. It provides a feasible and innovative way to estimate the influence of wind resistance on the dynamic balance accuracy of large mesh antenna, so as to compensate the wind resistance effect. Combined with the ground dynamic balancing requirements of a certain type of satellite mesh antenna, the whole finite element model of the mesh antenna is established, the simulation of ground dynamic balancing test is carried out, and the influence of wind resistance on the ground dynamic balancing results of the antenna is analyzed in this study, which provides important data for compensating the influence of wind resistance and ensuring the on-orbit balancing accuracy of the antenna.
Key words:    large mesh antenna    dynamic balance test    wind resistance equivalent    flow around circular cylinder   
收稿日期: 2020-10-08     修回日期:
DOI: 10.1051/jnwpu/20213930549
通讯作者: 贺尔铭(1964-),西北工业大学教授,主要从事飞机结构动力学与振动控制研究。e-mail:heerming@nwpu.edu.cn     Email:heerming@nwpu.edu.cn
作者简介: 陈鹏翔(1997-),西北工业大学硕士研究生,主要从事结构动力学与振动控制、力学仿真分析研究。
相关功能
PDF(2041KB) Free
打印本文
把本文推荐给朋友
作者相关文章
陈鹏翔  在本刊中的所有文章
贺尔铭  在本刊中的所有文章
姚瀚宇  在本刊中的所有文章
黄峻峰  在本刊中的所有文章
舒俊成  在本刊中的所有文章

参考文献:
[1] RODRIGUEZ E, STILES B W, DURDEN S L, et al. XOVWM:the next-generation ocean surface vector winds mission[C]//28th Conf on Hurricanes and Tropical Meteorology, Orlando, FL, 2008
[2] RODRIGUEZ E, GASTON R W, DURDEN S L, et al. A scatterometer for XOVWM, the extended ocean vector winds mission[C]//IEEE Radar Conference, 2009:1-4
[3] ALVAREZ-SALAZAR O S. Pointing architecture of SMAP's large spinning antenna[C]//AIAA Guidance, Navigation, and Control Conference, 2013:4560
[4] ZENG J, CHEN K S, BI H, et al. A Preliminary evaluation of the SMAP radiometer soil moisture product over United States and Europe using ground-based measurements[J]. IEEE Trans on Geoscience and Remote Sensing, 2016, 54(8):4929-4940
[5] 薛孝补, 朱海江, 吕旺, 等. 卫星大型旋转载荷动平衡控制应用研究[J]. 宇航学报, 2012, 33(8):1001-1005 XUE Xiaobu, ZHU Haijiang, LYU Wang, et al. Application research on dynamic balance control for spaceborne large-scale rotary payload[J]. Journal of Astronautics, 2012, 33(8):1001-1005(in Chinese)
[6] 王秋晓, 汪飞, 孔波. 一种改进的卫星旋转载荷动平衡的振动结构[J]. 振动与冲击, 2016, 35(3):204-208 WANG Qiuxiao, WANG Fei, KONG Bo. Improved vibrational mechanism for dynamic balance of satellite-borne rotating playload[J]. Journal of Vibration and Shock, 2016, 35(3):204-208(in Chinese)
[7] 姜广义, 王德友, 焦业秋. 大型发动机转子本机平衡技术试验研究[J]. 航空发动机, 2008(1):19-22 JIANG Guangyi, WANG Deyou, JIAO Yeqiu. Experimentd investigation of local balanced technique for large aeroengine rotor[J]. Aeroengine, 2008(1):19-22(in Chinese)
[8] 周秋峰. 直升机旋翼动平衡优化研究[D]. 南京:南京航空航天大学, 2013 ZHOU Qiufeng. Research on optimization of helicopter rotor dynamic balance[D]. Nanjing:Nanjing University of Aeronautics and Astronautics, 2013(in Chinese)
[9] 牛宝华, 姚瀚宇, 艾永强, 等. 星载天线地面动平衡试验仿真研究[J]. 航天制造技术,2019(3):32-36 NIU Baohua, YAO Hanyu, AI Yongqiang, et al. Dynamic balancing design simulation and ground test for satellite antenna[J]. Aerospace Manufacturing Technology, 2019(3):32-36(in Chinese)
[10] 龚燃. 美国"土壤湿度主动-被动探测"卫星将升空[J]. 国际太空, 2015(1):31-35 GONG Ran. NASA's soil moisture active-passive(SMAP) mission set to launch[J]. Space International, 2015(1):31-35(in Chinese)
[11] 王朋朋, 牛宝华, 艾永强, 等. 海洋二号卫星微波辐射计的动平衡设计仿真与试验[J]. 振动与冲击. 2016, 36(9):1-6 WANG Pengpeng, NIU Baohua, AI Yongqiang, et al. Dynamic balancing design simulation and test for HY-2A satellite microwave radiometer[J]. Journal of Vibration and Shock, 2016, 36(9):1-6(in Chinese)
[12] 邓歆献. 某雷达结构风荷载特性及抗风性能研究[D]. 成都:西南交通大学, 2017 DENG Xinxian. Study on wind load characteristics and resistance performance of a radar structure[D]. Chengdu:Southwest Jiaotong University, 2017(in Chinese)
[13] 李雪健. 较高雷诺数下串列方柱绕流的数值模拟[D]. 杭州:中国计量学院, 2014 LI Xuejian. Numerical simulation of flow around two prisms in tandem arrangement at high Reynolds numbers[D]. Hangzhou:China Jiliang University, 2014(in Chinese)
[14] 马亮, 钱光平. 非球形风沙粒子的低雷诺数绕流阻力特性研究[J]. 水动力学研究与进展A辑, 2011, 26(1):19-23 MA Liang, QIAN Guangping. The study on the lower Reynolds drag around nonspherical sand particles[J]. Chinese Journal of Hydrodynamics, 2011, 26(1):19-23(in Chinese)
[15] 沈国辉, 姚剑锋, 郭勇, 等. 直径30 cm圆柱的气动力参数和绕流特性研究[J]. 振动与冲击, 2020, 39(6):22-28 SHEN Guohui, YAO Jianfeng, GUO Yong, et al. Aerodynamic coefficient and flow characteristics of a 30 cm-diameter circular cylinder[J]. Journal of Vibration and Shock. 2020, 39(6):22-28(in Chinese)
[16] 邓小兵, 张涵信, 李沁. 三维方柱不可压缩绕流的大涡模拟计算[J]. 空气动力学学报, 2008, 26(2):167-172 DENG Xiaobing, ZHANG Hanxin, LI Qin. Large eddy simulation of 3-dimensional incompressible flow around a square cylinder[J]. Acta Aerodynamica Sinica, 2008, 26(2):167-172(in Chinese)
[17] HE Erming, YIN Geliang, HU Yaqi. Random vibration analysis and structural modification of satellite-borne equipment[J]. Applied Mechanics and Materials, 2014(455):310-313