|
|
论文:2021,Vol:39,Issue(3):539-548 |
|
|
引用本文： |
|
|
李文刚, 肖隐利, 路易聘, 曹志博, 吴娟. 基于OpenFOAM的正十二烷喷雾燃烧数值模拟[J]. 西北工业大学学报 |
|
|
LI Wengang, XIAO Yinli, LU Yipin, CAO Zhibo, WU Juan. Numerical simulation of n-dodecane spray combustion based on OpenFOAM[J]. Northwestern polytechnical university |
|
|
|
|
|
|
|
| 基于OpenFOAM的正十二烷喷雾燃烧数值模拟 |
|
| 李文刚, 肖隐利, 路易聘, 曹志博, 吴娟 |
|
| 西北工业大学 动力与能源学院, 陕西 西安 710072 |
| 摘要: |
| 为了深入理解喷雾射流的燃烧特性，基于OpenFOAM平台，采用有限速率PaSR燃烧模型和详细化学反应动力学相结合的方法，对ECN（engine combustion network）Spray A（正十二烷喷雾燃烧）无反应和有反应2种情况进行数值计算。无反应情况下验证了该喷雾模型的适用性和精确性，发现预测的液体和蒸气穿透长度、混合分数等喷雾特性参数与试验结果吻合很好；反应情况下分析了正十二烷喷雾点火经历的低温反应和高温点火2个过程，发现低温反应在未发生高温点火前持续放热，在高温点火后仍持续稳定进行，起到促进高温点火和稳定火焰作用；研究了不同燃油注入压力对点火延迟时间和火焰浮升高度的影响。 |
| 关键词:
喷雾燃烧
PaSR
正十二烷
火焰浮升高度
低温反应
|
|
| Numerical simulation of n-dodecane spray combustion based on OpenFOAM |
|
| LI Wengang, XIAO Yinli, LU Yipin, CAO Zhibo, WU Juan |
|
| School of Power and Energy, Northwestern Polytechnical University, Xi'an 710072, China |
| Abstract: |
| For the purpose of providing the scientific insights to combustion characteristics of spray jet, numerical calculations of reacting and non-reacting spray cases are performed for ECN (engine combustion network) Spray A (n-dodecane spray combustion) which coupled finite chemistry combustion model PaSR and detailed chemical reaction kinetics based on OpenFOAM. The applicability and accuracy of the spray model is verified in the non-reacting spray case, and it is found that the predicted spray characteristics such as the penetration length of liquid and vapor and the mixture fraction are in good agreement with the test results. The two processes of low-temperature reaction and high-temperature ignition experienced by n-dodecane spray ignition are analyzed in reacting spray case, and it is found that the low-temperature reaction continues to exothermic before high-temperature ignition, and continues to proceed stably after high-temperature ignition, which promotes high-temperature ignition and flame stability. Finally, the effects of different fuel injection pressures on ignition delay time and flame lift-off length are studied. |
| Key words:
spray combustion
PaSR
n-dodecane
flame lift-off length
low-temperature reaction
|
|
| 收稿日期: 2020-08-18
修回日期:
|
| DOI: 10.1051/jnwpu/20213930539 |
| 基金项目: 航空科学基金（2020Z039053005）资助 |
| 通讯作者:
Email： |
| 作者简介: 李文刚(1997-),西北工业大学硕士研究生,主要从事燃烧室的设计与仿真研究。
|
|
|
|
|
|
|
|
参考文献: |
|
|
[1] Engine Combustion Network. Engine combustion network database[EB/OL]. (2010-10-25)[2020-06-15]. http://www.sandia.gov/ecn/
[2] LUO Z, SOM S, SARATHY S M, et al. Development and validation of an n-dodecane skeletal mechanism for spray combustion applications[J]. Combustion Theory and Modelling, 2014,18(2):187-203
[3] NARAYANASWAMY K, PEPIOT P, PITSCH H. A chemical mechanism for low to high temperature oxidation of n-dodecane as a component of transportation fuel surrogates[J]. Combust and Flame, 2014,161(4):866-884
[4] RANZI E, FRASSOLDATI A, STAGNI A, et al. Reduced kinetic schemes of complex reaction systems:fossil and biomass-derived transportation fuels[J]. International Journal of Chemical Kinetics, 2014,46(9):512-542
[5] YAO Tong, PEI Yuanjiang, ZHONG Beijing, et al. A compact skeletal mechanism for n-dodecane with optimized semi-global low-temperature chemistry for diesel engine simulations[J]. Fuel,2017,191:339-349
[6] LYLE M P, JULIEN M, CAROLINE L G, et al. Relationship between diesel fuel spray vapor penetration/dispersion and local fuel mixture fraction[J]. SAE Internatioal Journal of Engines, 2011,4(1):764-799
[7] ERRICO G D', LUCCHINI T, CONTINO F, et al. Comparison of well-mixed and multiple representative interactive flamelet approaches for diesel spray combustion modelling[J]. Combustion Theory and Modelling, 2014, 18(1):65-88
[8] BHATTACHARJEE S, HAWORTH D C. Simulations of transient n-heptane and n-dodecane spray flames under engine-relevant conditions using a transported PDF method[J]. Combustion and Flame, 2013,160(10):2083-2102
[9] SALEHI F, CLEARY M J, MASRI A R, et al. Sparse-lagrangian MMC simulations of an n-dodecane jet at engine-relevant conditions[J]. Proceedings of the Combustion Institute, 2017, 36:3577-3585
[10] ARMIN Wehrfritz, OSSI Kaario, VILLE Vuorinen, et al. Large eddy simulation of n-dodecane spray flames using flamelet generated manifolds[J]. Combustion and Flame, 2016, 167:113-131
[11] CHENG Gong, MEHDI Jangi, TOMMASO Lucchini, et al. Large eddy simulation of air entrainment and mixing in reacting and non-reacting diesel sprays[J]. Flow Turbulence and Combustion, 2014, 93(3):385-404
[12] CHOMIAK J, KARLSSON A. Flame liftoff in diesel sprays[J]. Symposium on Combustion, 1996, 26(2):2557-2564
[13] PENG F K, NORDIN N. Numerical Investigation of mesh/turbulence/spray interaction for diesel applications[J/OL]. (2005-05-11)[2020-06-15]. https//www.sae.org/publications/technical-papers/content/2005-01-2115
[14] PEI Yuangjiang. Transported PDF modelling of spray combustion at practical diesel engine conditions[D]. Sydney, the University of New South Wales, 2013
[15] MASTORAKOS E. Ignition of turbulent non-premixed flames[J]. Progress in Energy and Combustion Science, 2009, 35:57-97
[16] BHATTACHARJEE S, HAWORTH D C. Simulations of transient n-heptane and n-dodecane spray flames under engine-relevant conditions using a transported PDF method[J]. Combustion & Flame, 2013, 160(10):2083-2102 |
|
|
|
|
|
|
|
