|
|
论文:2020,Vol:38,Issue(6):1198-1209 |
|
|
引用本文： |
|
|
李乐, 索建秦, 郑龙席. 旋向对中心分级燃烧室流场及温度场影响研究[J]. 西北工业大学学报 |
|
|
LI Le, SUO Jianqin, ZHENG Longxi. Effect of Rotating Direction on Flow and Temperature Field of Concentric Staged Combustor[J]. Northwestern polytechnical university |
|
|
|
|
|
|
|
| 旋向对中心分级燃烧室流场及温度场影响研究 |
|
| 李乐, 索建秦, 郑龙席 |
|
| 西北工业大学 动力与能源学院, 陕西 西安 710072 |
| 摘要: |
| 采用数值模拟方法对中心分级多点直喷燃烧室冷/热态流场和温度场进行研究，揭示了流场和温度场之间的相互作用机理，获得了旋流器旋向对流场和温度场的影响规律。结果表明：冷态条件下，旋流器不同旋向时均形成了张角为17°的中心回流区，但同旋向下形成的中心回流区尺寸更大；随着燃烧释热的加入，不同旋向燃烧室形成了尺寸相同的中心回流区，而且张角增大为45°；不同轴向位置的切向速度分布云图依次形成"圆形"、"菱形"、"椭圆形"和"上下对称"结构，分别表征了中心回流区开始形成、初步发展、充分发展和逐渐消失4个过程；燃烧室内旋流空气切向速度越小，近出口中心位置的轴向速度越大，导致燃烧室出口热点温度越高，因此旋流器同旋向时具有更好的出口温度分布因数。 |
| 关键词:
燃烧室
旋流器旋向
流场
回流区
温度场
|
|
| Effect of Rotating Direction on Flow and Temperature Field of Concentric Staged Combustor |
|
| LI Le, SUO Jianqin, ZHENG Longxi |
|
| School of Power and Energy, Northwestern Polytechnical University, Xi'an 710072, China |
| Abstract: |
| The characteristic of cold/reaction flow and temperature field were investigated by using the numerical simulation for concentric staged multi-point direct injection combustor. The interaction mechanism between the flow field and the temperature field was revealed, and the effect rules of the swirlers rotating direction on the flow and temperature field were obtained. The results indicated that the central recirculation zone with divergence angle of 17 degrees is formed under cold condition by using the co-rotating swirlers and counter-rotating swirlers, and the central recirculation zone size of co-rotating swirlers is larger than that of counter-rotating swirlers. Heat release of the flame causes the similar central recirculation zone shape is formed by using the different rotating direction swirlers, and the divergence angle increased to 45 degrees. Tangential velocity contour of different aixal sections are undergone the "circular shape", "diamond shape", "elliptical shape" and "upper-lower symmetrical" structures, which represent the formation of the central recirculation zone, initial development, full development and gradual disappearance respectively. With the decreasing of tangential velocity of the swirling air in the combustor, the axial velocity at center of near outlet and the hot spot temperature at the outlet of combustor increase. Therefore, the co-rotating swirlers combustor has a better outlet temperature distribution factor (OTDF). |
| Key words:
combustor
rotating direction
flow field
recirculation zone
temperature field
|
|
| 收稿日期: 2020-01-02
修回日期:
|
| DOI: 10.1051/jnwpu/20203861198 |
| 基金项目: 国家科技重大专项（2017-Ⅲ-0002-0026）资助 |
| 通讯作者:
Email： |
| 作者简介: 李乐(1991-),西北工业大学博士研究生,主要从事航空发动机燃烧技术研究。
|
|
| 相关功能 |
|
|
|
|
| 作者相关文章 |
|
| 李乐 在本刊中的所有文章 |
| 索建秦 在本刊中的所有文章 |
| 郑龙席 在本刊中的所有文章 |
|
|
|
|
|
|
|
|
参考文献: |
|
|
[1] LEFEBVRE A H, BALLAL D R. Gas Turbine Combustion[M]. New York:CRC Press, 2010
[2] 金如山, 索建秦. 先进燃气轮机燃烧室[M]. 北京:航空工业出版社, 2016 JIN Rushan, SUO Jianqin. Advanced Gas Turbine Combustor[M]. Beijing:Aviation Industry Press, 2016(in Chinese)
[3] DHANUKA S K, DRISCOLL J, MONGIA H. Instantaneous Flow Structures in a Reacting Gas Turbine Combustor[C]//AIAA Joint Propulsion Conference & Exhibit, Hartford, 2008
[4] ATESHKADI A, MCDONELL V G, SAMUELSEN G S. Effect of Mixer Geometry on Fuel Spray Distribution, Emissions and Stability[C]//AIAA Aerospace Sciences Meeting and Exhibit, Reno, 2013
[5] LI G, GUTMARK E J. Experimental and Numerical Studies of the Velocity Field of a Triple Annular Swirler[C]//ASME Turbo Expo, Amsterdam, 2002
[6] LI G, GUTMARK E J. Boundary Condition Effects on Non-Reacting and Reacting Flows in a Multi-Swirl Combustor[J]. AIAA Journal, 2006, 44(3):444-456
[7] 赵自强, 何小民, 丁国玉, 等. 旋流器流量分配对三级旋流流场特性的影响[J]. 推进技术, 2017,38(1):134-140 ZHAO Ziqiang, HE Xiaomin, DING Guoyu, et al. Effects of Air Proportions on Flow Characteristics of Swirling Flow Generated by Triple-Swirlers[J]. Journal of Propulsion Technology, 2017,38(1):134-140(in Chinese)
[8] 丁国玉, 何小民, 薛冲, 等. 头部及掺混孔对三级旋流器燃烧室出口温度分布影响的试验[J]. 航空动力学报, 2015,30(4):807-813 DING Guoyu, HE Xiaoming, XUE Chong, et al. Experiment on Effect of Dome and Dilution Holes on Outlet Temperature Distribution for Triple Swirler Combustor[J]. Journal of Aerospace Power, 2015,30(4):807-813(in Chinese)
[9] 陈浩, 杨金虎, 刘存喜, 等. 中心分级高温升燃烧室的油气掺混特性[J]. 燃烧科学与技术, 2016,22(5):464-469 CHEN Hao, YANG Jinhu, LIU Cunxi, et al. Fuel-Air Mixing Properties of Center-Staged High Temperature Rise Combustor[J]. Journal of Combustion Science and Technology, 2016,22(5):464-469(in Chinese)
[10] 于涵, 索建秦, 朱鹏飞, 等. 中心分级贫油直喷(LDI)燃烧室流动及污染排放特性研究[J]. 西北工业大学学报, 2018,36(5):816-823 YU Han, SUO Jianqin, ZHU Pengfei, et al. The Characteristic of Flow Field and Emission of a Concentric Staged Lean Direct Injection(LDI) Combustor[J]. Journal of Northwestern Polytechnical University, 2018,36(5):816-823(in Chinese)
[11] YU Han, SUO Jianqin, LIANG Hongxia, et al. Experimental Study on Effusion Cooling with Tangential Air Inlet[C]//Propulsion and Energy Forum, Salt Lake City, 2016
[12] 常峰, 索建秦, 梁红侠, 等. 同心圆式主副模分区燃烧组织燃烧室数值研究[J]. 推进技术, 2012,33(5):760-764 CHANG Feng, SUO Jianqin, LIANG Hongxia, et al. Numerical Study of Co-Axial Pilot and Main Module Combustor[J]. Journal of Propulsion Technology, 2012,33(5):760-764(in Chinese)
[13] 于涵, 孙付军, 李乐, 等. 一种贫油直接喷射及混合低污染燃烧室[P]. CN 201710608804.3, 2019-08-09 YU Han, SUN Fujun, LI Le, et al. A Lean Direct Injection and Mixed Low-emission Combustor, CN 201710608804.3[P], 2019-08-09(in Chinese)
[14] GIRIDHARAN M G, HELD T J, MONGIA H C. A Wet Emissions CFD Model Based on Laminar Flamelet Approach[C]//International Society of Air Breathing Engines, 2003
[15] Li Y J, ZHENG H T, MU Y, et al. Application of Turbulent Models on Simulation of Intense Swirling Flow Combustor[C]//Asia-Pacific Power and Energy Engineering Conference, Wuhan, 2011
[16] HUANG Y, YANG V. Dynamics and Stability of Lean Premixed Swirl-Stabilized Combustion[J]. Progress in Energy and Combustion Science, 2009,35(4):293-364
[17] 于涵, 索建秦, 郑龙席. 带收敛出口的单元贫油直喷燃烧室冷态和热态流动特性研究[J]. 推进技术, 2019,40(3):608-618 YU Han, SUO Jianqin, ZHENG Longxi. Investigation of Non-Reaction and Reaction Flow Characteristic of Single Element Lean Direct Injection Combustor with Convergent Outlet[J]. Journal of Propulsion Technology, 2019,40(3):608-618(in Chinese)
[18] 宁榥, 高歌. 燃烧室气动力学[M]. 北京:科学出版社, 1987 NING Huang, GAO Ge. Combustor Aerodynamics[M]. Beijing:Science Press, 1987(in Chinese) |
|
|
|
相关文献: |
|
|
1．常江, 吴功平, 吴浩东, 郝雪杰.点火通道对点火装置工作过程影响分析[J]. 西北工业大学学报, 2018,36(6): 1193-1201 |
|
|
|
|
|
|
