论文:2020,Vol:38,Issue(2):246-252
引用本文:
穆阳, 李皓, 王震, 苗毅, 段士昌. 无人目标机隐身优化设计与改装技术研究[J]. 西北工业大学学报
MU Yang, LI Hao, WANG Zhen, MIAO Yi, DUAN Shichang. Optimized Stealth Design and Remolding of Target Unmanned Aerial Vehicle[J]. Northwestern polytechnical university

无人目标机隐身优化设计与改装技术研究
穆阳1, 李皓1, 王震1, 苗毅1, 段士昌2
1. 中国飞行试验研究院 航电所, 陕西 西安 710089;
2. 西北工业大学 凝固技术国家重点实验室, 陕西 西安 710072
摘要:
针对当前雷达性能试验过程中对低可探测目标机的迫切需求以及磁性吸波涂层应用时存在的面密度大等诸多缺陷,通过优化设计吸收剂含量和涂层厚度,获得一种以碳纳米管(CNTs)为主吸收剂的轻质电损耗型吸波涂层,利用该涂层对某型无人目标机进行隐身优化设计和改装,飞行试验验证了机载雷达对无人目标机的作用距离。结果表明:当CNTs含量接近15%时,2.5 mm厚的吸波涂层在8.2~12.4 GHz频段内具有优异的吸波性能,反射率均能达到-8 dB以下。经设计涂覆处理后,无人目标机各强散射中心得到有效减弱,飞行试验结果表明涂覆后无人目标机的雷达散射截面(RCS)相比涂覆前缩减可达20 dB左右。
关键词:    碳纳米管    吸波涂层    隐身改装    雷达散射截面    雷达作用距离   
Optimized Stealth Design and Remolding of Target Unmanned Aerial Vehicle
MU Yang1, LI Hao1, WANG Zhen1, MIAO Yi1, DUAN Shichang2
1. Department of Avionics, Chinese Flight Test Establishment, Xi'an 710089, China;
2. State Key Laboratory of Solidification Processing, Northwestern Polytechnical University, Xi'an 710072, China
Abstract:
In order to satisfy the imperious requirements of low-detectable target aircraft in the current test and evaluation of airborne radar and to remedy the numerous defects of magnetic microwave absorbing coating in the practical application, a new type of light-weight electric loss coating with the carbon nanotubes(CNTs) was proposed by the optimal design of the absorbent content and coating thickness. A type of target unmanned aerial vehicle(UAV) with representative non-stealth structure was remolded by the present type of coating, and the detection range of airborne radar to the remolded UAV was obtained in the flight test. The results reveal that the microwave absorbing coating with a thickness of 2.5mm has the optimized microwave absorbing properties at a CNTs content of 15wt.%, and the reflection loss value can be inferior to -8dB over the whole X band. The intensity level of scattering center of the UAV degrades after coated, and the radar cross section (RCS) of coated UAV decreases by 20dB in the flight test.
Key words:    CNTs    microwave absorbing coating    stealth remolding    RCS    radar detection range   
收稿日期: 2019-04-14     修回日期:
DOI: 10.1051/jnwpu/20203820246
基金项目: 国家自然科学基金(51502236)资助
通讯作者:     Email:
作者简介: 穆阳(1989-),中国飞行试验研究院高级工程师、博士,主要从事隐身材料、隐身设计研究。
相关功能
PDF(1133KB) Free
打印本文
把本文推荐给朋友
作者相关文章
穆阳  在本刊中的所有文章
李皓  在本刊中的所有文章
王震  在本刊中的所有文章
苗毅  在本刊中的所有文章
段士昌  在本刊中的所有文章

参考文献:
[1] 桑建华. 飞行器隐身技术[M]. 北京:航空工业出版社, 2013:1-5 SANG Jianhua. Low-Observable Technologies of Aircraft[M]. Beijing:Aviation Industry Press, 2013:1-5(in Chinese)
[2] 刘顺华, 郭辉进. 电磁屏蔽与吸波材料[J]. 功能材料与器件学报, 2002, 8(3):213-217 LIU Shunhua, GUO Huijin. Electromagnetic Interference Shielding and Wave-Absorbing Materials[J]. Journal of Functional Materials and Devices, 2002, 8(3):213-217(in Chinese)
[3] MU Yang, ZHOU Wancheng, LUO Fa, et al. Electromagnetic Interference Shielding Effectiveness of SiCf/SiC Composites with PIP-SIC Interphase after Thermal Oxidation in Air[J]. Journal of Materials Science, 2014, 49:1527-1536
[4] TIAN Hao, LIU Haitao, CHENG Haifeng. A High-Temperature Radar Absorbing Structure:Design, Fabrication, and Characterization[J]. Composites Science and Technology, 2014, 90:202-208
[5] LIU Haitao, CHENG Haifeng, WANG Jun, et al. Dielectric Properties of the SiC Fiber-Reinforced SiC Matrix Composites with the CVD SiC Interphases[J]. Journal of Alloys and Compounds, 2010, 491:248-251
[6] KONG Luo, YIN Xiaowei, HAN Meikang, et al. Carbon Nanotubes Modified with ZnO Nanoparticles:High-Efficiency Electromagnetic Wave Absorption at High-Temperatures[J]. Ceramics International, 2015, 41:4906-4915
[7] ZHANG Yajun, YIN Xiaowei, YE Fang. Effects of Multi-Walled Carbon Nanotubes on the Crystallization Behavior of PDCs-SiBCN and Their Improved Dielectric and EM Absorbing Properties[J]. Journal of the European Ceramic Society, 2014, 34:1053-1060
[8] MU Yang, ZHOU Wancheng, HU Yang, et al. Temperature-Dependent Dielectric and Microwave Absorption Properties of SiCf/SiC-Al2O3 Composites Modified by Thermal Cross-Linking Procedure[J]. Journal of the European Ceramic Society, 2015, 35(11):2991-3003
[9] 高正娟, 曹茂盛, 朱静. 复合吸波材料等效电磁参数计算的研究进展[J]. 宇航材料工艺, 2004(4):12-15 GAO Zhengjuan, CAO Maosheng, ZHU Jing. Development in Study of Effective Electromagnetic Parameters of Absorbing Composite[J]. Aerospace Materials & Technology, 2004(4):12-15(in Chinese)