|
|
论文:2013,Vol:31,Issue(1):60-66 |
|
|
引用本文： |
|
|
刘雁, 陈党民, 柳黎光, 王航, 程凯. 离心式压缩机出口动态压力的单重分形特征研究[J]. 西北工业大学 |
|
|
Liu Yan, Chen Dangmin, Liu Liguang, Wang Hang, Cheng Kai. Exploring Monofractal Characteristics of Dynamic Pressure at Exit of Centrifugal Compressor[J]. Northwestern polytechnical university |
|
|
|
|
|
|
|
| 离心式压缩机出口动态压力的单重分形特征研究 |
|
| 刘雁1,2, 陈党民2, 柳黎光2, 王航2, 程凯2 |
|
1. 西北工业大学 机电学院, 陕西 西安 710072;
2. 西安陕鼓动力股份有限公司, 陕西 西安 710072 |
| 摘要: |
| 以800 kW离心压缩机系统在不同工况下的出口动态压力特征为分析对象,通过分析其单重分形特征,研究了系统在小流量工作状态下,从稳定工作状态进入失稳状态的复杂特性。首先,详细分析了在不同工况下的动态压力波形状态,并研究出了其自相关函数及曲线。进一步,分析了其Hurst参数及方差的变化,并捕获到一些重要的特征。研究结果表明:当压缩机正常运行时,其自相关函数曲线表现出明显的随机特征,并且方差较小。然而,当系统进入失稳状态时,其自相关函数曲线表现出明显的重尾分布特征,而且方差较高。另外,研究显示Hurst参数可以明显表示系统由稳态进入失稳的过程。所得到的分析结果将为实现离心压缩机的初始喘振预测及防喘振控制器的设计带来新的思路。 |
| 关键词:
离心压缩机
流动失稳
单重分形
自相关函数
Hurst参数
|
|
| Exploring Monofractal Characteristics of Dynamic Pressure at Exit of Centrifugal Compressor |
|
| Liu Yan1,2, Chen Dangmin2, Liu Liguang2, Wang Hang2, Cheng Kai2 |
|
1. School of Mechatronics, Northwestern Polytechnical University, Xi'an 710072, China;
2. Xi'an Shaangu Power Co.Ltd, Xi'an 710075, China |
| Abstract: |
| We study the complexity of a centrifugal compressor with 800 kw when its flow changes from stable tounstable state under the low flux condition.First, we change its dynamic pressure by controlling the opening of thesurge prevention valve at the exit and analyze its dynamic pressure wave properties under various working conditionsand obtain its autocorrelation functions and curves.Second, we analyze the Hurst parameters, autocorrelation func-tions and variances to obtain the monofractal characteristics of the centrifugal compressor.Finally, we tested the dy-namic pressure at the exit of a certain large-type centrifugal compressor.The test results, given in Figs.2 through7 and Table 1, and their analysis show preliminarily that: (1) when the centrifugal compressor is working undernormal condition, its autocorrelation function curve demonstrates apparent stochastic characteristics, and its vari-ance is lower; however, when it is working in an unstable condition, its autocorrelation function curve demonstratesan apparent heavy tail distribution, and its variance is higher; (2) the Hurst parameter can effectively show thechange from stable to unstable state.Our exploration results can be used to predict the incipient surge of a centrifu-gal compressor and design its surge controller. |
| Key words:
centrifugal compressors
fluxes
pressure
surges(fluid)
valves(mechanical);monofractal charac-teristic
autocorrelation function
Hurst parameter
|
|
| 收稿日期: 2012-05-10
修回日期:
|
| DOI: |
| 基金项目: 国家“973”计划(2012CB026002);国家“863”计划(SS2012AA052303)资助 |
| 通讯作者:
Email： |
| 作者简介: 刘雁(1974-)，女，西北工业大学讲师、博士，主要从事透平机械流动失稳、机算机网络动力学研究。
|
|
| 相关功能 |
|
|
|
|
| 作者相关文章 |
|
| 刘雁 在本刊中的所有文章 |
| 陈党民 在本刊中的所有文章 |
| 柳黎光 在本刊中的所有文章 |
| 王航 在本刊中的所有文章 |
| 程凯 在本刊中的所有文章 |
|
|
|
|
|
|
|
|
参考文献: |
|
|
[1] 靳伍银,刘飞跃等.离心压缩机的防喘振控制.兰州理工大学学报,2007,3,42-45Jin W Y,Liu F Y,et al.An Anti-Surge Control for Centrifugal Compressor.Journal of Lanzhou University of Technology,2007,3: 42-45 (in Chinese)
[2] 王 博,郭振霞.离心压缩机防喘振控制系统设计.风机技术,2009,(2): 53-59Wang B,Guo Z X.Design of Centrifugal Compressor Anti-Surge Control System.Compressor,Blower ＆ Fan Technology,2009,(2): 53-59 (in Chinese)
[3] 童志庭,张靖煊等.不同进口畸变下低速压气机近失速状态非定常特征.工程热物理学报,2006,(1): 51－53Tong Z T,Zhang J X,et al.Unsteady Flow Behavior of Near-Stall States in Low-Speed Compressor under Different Distortions．Journal of Engineering Thermophysics,2006,(1): 51-53 (in Chinese)
[4] 徐 纲,聂超群等.低速轴流压气机顶部微量喷气控制失速机理的数值模拟.工程热物理学报,2004,(1): 37-40Xu G,Nie C Q,et al.Numerical Simulation of Micro Injection in A Low-Speed Axial Compressor.Journal of Engineering Ther-mophysics,2004,(1): 37-40 (in Chinese)
[5] Shehata R S,Abdullah H A,et al.Variable Structure Surge Control for Constant Speed Centrifugal Compressors.Control Engi-neering Practice,2009,(2): 815-833
[6] Amanifard N,Nariman Z N,et al.Modeling of Multiple Short-Length-Scale Stall Cells in an Axial Compressor Using EvolvedGMDH Neural Networks.Energy Conversion and Management,2008,(10): 2588-2594
[7] Moghaddama J J,Farahanib M H,et al.A Neural Network-Based Sliding-Mode Control for Rotating Stall and Surge in AxialCompressors.Applied Soft Computing,2011,(1): 1036-1043
[8] Fontaine D,Liao S,et al.Nonlinear Control Experiments on an Axial Flow Compressor.IEEE Trans on Control Systems Tech-nology,2004,(9): 683-693
[9] Williams F,Huang X Y.Active Stabilization of Compressor Surge.Journal of Fluid Mechanics,1989,(1): 245-262
[10] Greitzer E M.Surge and Rotating Stall in Axial Flow Compressors: Part I-Theoretical Compression System Model.ASME Journalof Engineering for Power,1976
[11] Alamir M.Nonlinear Robust Controller for Rotating Stall and Surge in Axial Flow Compressors.IEEE Conference on Decisionand Control,2000,(2): 1335-1340
[12] Leland W,Taqqu M,Willinger W,et al.On The Self-Similar Nature of Ethernet Traffic.IEEE/ACM Trans on Networking,1994,2(1): 1-15
[13] 张济忠.分形.北京: 清华大学出版社,1995Zhang J Z.Fractal.Beijing: Tsinghua University Press,1995 (in Chinese) |
|
|
|
|
|
|
|
